Treating Ed Ted - the first step: Continued

Hello once again from Cy Bear - Isobel has agreed that I continue to describe what has been, and is, happening to my new friend Ed Ted.  HEALTH WARNING:  some of the following images may be somewhat alarming to some readers!

Pattern pieces for Ed Ted's head, with ears and eyes in centre, and cotter pin attaching head to body next to them

The picture also shows the two tools Isobel has used to perform the operations on Ed Ted, and the ironing table on which they have been performed.  We've had to use newspaper underneath him, because as we take out the stuffing, a heap of dust comes out too. It's meant that each piece has been brushed so that as much dust and remaining kapok is removed before they are soaked and prepared for applique work.   Isobel has been sneezing her head off (and coughing too) while she's been doing it.  Very fortunately, I'm not so afflicted!  It all sounds most uncomfortable.

These are the contents of Ed Ted's tummy.  Again, kapok and wood chips.

This has now all been collected, put in a plastic bag and placed in the garbage bin, together with all the kapok in Ed's arms and legs, which can be seen in the next picture

Ed Ted's arms, around the tummy contents

Here one can see how his paw pads have disintegrated over the years. There had been attempts to sew them back on, but because the fabric involved was somewhat brittle, it had not been altogether successful.  Which is why, in the first photograph of the poor chap, we saw him with bandages and socks on to keep the stuffing together.

In this picture, you can see the enormous cotter pins that were used to keep Ed's limbs attached to his body.  Isobel raided Peter's tool-box for a pair of pliers and managed to unwind them so that we could take them out of three out of four attachments.  The fourth had to be cut around, but we should be able to make a pattern without that particular limb, so when he's finally made up, Ed will have two arms and two legs that match.

Here is a photograph of the five cotter pins together, before disposal in the garbage bin, together with the pliers that managed to extract them without causing too much damage to Ed's remaining body fabric. They took up a fair amount of space within his body, didn't they?

Now the first stage of Ed's rejuvenation thereapy is over.  Currently, as Isobel types this post, all the pieces are soaking in warm, soapy water in order to remove the inevitable grime that has accrued after years of playtime and other adventures with RFE and others.  They will be rinsed out before Isobel goes to bed tonight, and hopefully will be dry enough for ironing tomorrow - when Isobel has a whole lot of laundry to deal with anyway.

We've asked for a biography of Ed Ted so we can include it in a future blog, but - so far - it's not arrived.  RFE is travelling, so it may prove difficult to pin him down, but we'll keep trying.

It's been a long blog today, but there are a lot of pictures to break up the prose!  Hope you've not been too upset by some of them.  But, to be fair to Ed Ted, they had to be shown.  Cheers for now.  Cy Bear

Treating Ed Ted - the first step

Greetings once more Everyone:  Cy Bear allowed to contribute again, and pleased to be talking to you.
 
One development since we last posted about Ed Ted is that Isobel has received the swatches she asked for to make his new outer covering from her local suppliers.  Although there was a possibility this could have been done in mohair, we heard today that the cost of using it was higher than Isobel was prepared to consider, so we've had to tell our Etsy contact FatPumpkinBear in USA that we won't be doing business with them after all.  We're very grateful for all the help Karen from that site was prepared to give us, but the budget for the project would have been exceeded before we'd started had we gone down that route.   Isobel's normal UK supplier for plush fur fabric has provided a pretty near match - so, Ed Ted is going to be made in Honey Fur Fabric.  The order will be sent once Isobel and husband, Peter, have returned from a routine hospital visit in Salisbury  tomorrow.

So, while waiting to receive the sample fabrics, Isobel began the delicate task of taking Ed Ted to pieces.  She found that by and large, the seams were in very good shape, although some had obviously had to have attention in order to keep the old fellow in shape.  Even though the pictures we've shown of him show that his stuffing was in danger of coming out from his legs, they had actually retained their shape pretty well.  The worst treatment had been meted out to Ed's arms, which were in a very poor condition, but now the seams have been unpicked, Isobel is confident of being able to take a good pattern from all the original pieces.  She  can then applique the old bits onto a backing fabric and sew them in at the same time as sewing up the new outside covering.  This is method she established with Little Red Ted. (The story of that was contained in three posts in early April - see www.ColdhamCuddliescalling.blogspot.com/The Rejuvenation of Little Red Ted).

Ed Ted is now in pieces and Isobel has thrown out the original stuffing - which caused her to do a lot of coughing and sneezing as she was dealing with it.  Here are some pictures she took as she set to work with her "quick-unpic" and scissors.

Ed Ted's front, showing the wood chip stuffing and kapok

This was the first seam Isobel "attacked", and then she separated the head from the body.  The stuffing from the head is shown next:

The nose is wood chips:  the rest kapok

When Isobel was taking the head pieces apart, she discovered that the nose had been embroidered through the fabric into the wood chips:  it made what remained of Ed's nose a little difficult to unpick, but she achieved it without damaging the outer fabric, thus preserving the shape for creating the template for later work.  Once the stuffing had been removed, it became obvious that the next stage (once all the pieces had been undone) would be to scrape the remaining stuffing sticking to the fabric and washing each piece by hand.  That's going to be needed in order for Isobel to be able to get the correct shape for each piece before she can applique them on to the backing fabric. Some ironing is likely to be required as well. You can see how curled up the seams are - and most of the kapok has been scraped off the material.

Head pieces, plus ears and eyes, and cotter pin attaching head to the body

Now, I could go on all night, but this post would then be too long - so I'll finish for tonight, and Isobel or I will continue with the next post - hopefully tomorrow.  Bye for now.  Cy Bear

First Bulletin on Ed Ted's treatment

Ed Ted wth some bandages removed

Following Cy Bear's introduction of Ed Ted, we thought you'd like a quick update on what is happening (or not) with the poor fellow.

I've heard back from Ed Ted's Best Friend, RFE, and he's given me carte blanche as to what I do with him to make him better.  That should cut down on the time frame for his treatment, as it's my intention - if I do go ahead with setting up the Coldham Soft Toy Clinic - to keep the patient's family fully informed at each relevant stage of progress.  If they're not an Etsy member, that can take time.  RFE is a busy chap, spending time in UK, Dubai and Italy, when he's not in New York (or some place else!)  So. he's difficult to pin down, to say the least.

The UK fabric supplier I've already contacted for swatches has yet to come back to me - but they have more than one shop location in the south of England, and the colours I've specified may not all be in the same place.  So there is likely to be a delay in finding the rolls from which to cut the swatches.

In the interim, I was checking on the Etsy Activity site of www.coldhamcuddlies.etsy.com last night and found one of my Circle friends had favourited a site called FatPumpkinBear - based somewhere in the great USA.  The name was enough to catch my attention, so I had a further look - and lo and behold, Karen the site proprietor supplies Bear fabrics, among other activities on Etsy.

We happened to be online at the same time yesterday evening and I think's she's actually got some golden mohair fabric (rather than the plush fur I normally use) which, allowing for the differences computer colours can be to real life, looks to be to be spot on. There were a couple of others sample pictures she sent which might also be a good match, so I've asked for swatches from her too.  So, I will have to hope that US Mail and Royal Mail co-operate and that I can soon be able to make a decision and place an order.

Ed Ted's next treatment stage is for me to take him to pieces and make cardboard patterns from which to cut out his new form - both in the fur (when it eventually arrives) as well as the calico base on which I shall applique his existing pattern pieces, thus preserving what I can of his original body.  From the pictures already shown and those that follow, you can see that he's in pretty good shape, except for his arms.  Also, his stuffing is dangerous - being wood chippings (as was the practise when Ed Ted was new) and kapok filling, both inflammable and thus a real fire hazard.  When one thinks of the open wood,coal and gas fires that were prevalent when he and RFE were young and playing together, it's little short of horrifying, isn't it?  But, then, no one realised it then......so, it's up to me to make him a safe Bear to play with.

Ed Ted from the left side, with his eye hanging down

Right:  that's enough for tonight's bulletin.  We've got a daughter for lunch tomorrow, which may prevent much getting done tomorrow.  So, there may not be a post from either Cy nor me until early next week.  Isobel